Sea Ray 320 Sundancer Manual do Proprietário

320 SundancerOwner’s Manual Part Number: MRP 1803608Sea RayOwner’sManual

320 Sundancer® (355 Sundancer®)viii • TABLE OF CONTENTS •SECTION 5 • FUEL SYSTEM1. Fuel System ...

6.12SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)12 VOLT ACCESSORY RECEPTACLE(FIG. 6.12.3)9. LIGHTINGYour boat is equipped with a varie

6.13SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)EXTERIOR LIGHTS(FIG. 6.13.1)MAST NAV. LIGHTBULB REPLACEMENTFUSE TYPE BULB#12V10WPERKO

6.14SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)INTERIOR LIGHTS(FIG. 6.14.1)ROUND HEAD LIGHTCDBCBACBULB REPLACEMENTXELOGEN 12V 10WBI-P

6.15SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)SWITCH FUNCTION & LOCATIONS(FIG. 6.15.1)AIR CONDITIONERCONTROL PANELTV ANTENNA/CA

6.16SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)Never operate 120 volt shore power at less than 110volts.! CAUTIONEXTREME HAZARD – S

6.17SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)MAIN SHORE POWER BREAKER BOX(IN TRANSOM STORAGE COMPARTMENT)(FIG. 6.17.2)2. On The Do

6.18SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)3. On The Boat: 120 Volt or 220 Volt MainDistribution Panel (MDP)A.POWER Light ON. RE

6.19SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)Disconnect the power cable from power sourcebefore performing maintenance.! WARNING1

6.20SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)120 Volt AC Breakers AmperageShore 30Generator 50Alcohol/Electric Stove (Opt) 20Stove

6.21SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)15. GROUND FAULT INTERRUPTER RECEPTACLE (GFI)Ground fault interrupter receptacle

ix320 Sundancer® (355 Sundancer®)SECTION 9 • CARE & REFINISHING1. Paint, Cleaning Agents and Other Substances ... 9.12. Fiberglass & Gelcoa

6.22SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)A. INTERNATIONAL RECEPTACLEAll readily accessible 220V outlets are protectedby a Resid

6.23SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)ONOFFONOFFONOFFONOFFONOFFONOFFONOFFONOFFONOFFPORTIGNITIONSTBDIGNITIONACCESSORYREFRIG

6.24SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)ONOFFONOFFONOFFONOFFONOFFONOFFSTOVE01020 3040120 VOLT ACOUTLETS/REFRIGERATORWATER HEA

6.25SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)ONOFFONOFFONOFFONOFFONOFFONOFFONOFFONOFFONOFFPORTIGNITIONSTBDIGNITIONACCESSORYREFRIG

6.26SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)Never disconnect the green wire (safety ground) fromthe engine terminal.! CAUTION17.

6.27SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)+–TRANSOMZINC ANODETRIM TABSZINC ANODEZINC ANODEON TRIM TABS19. AC & DC ELECTRICAL

6.28SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)BONDING HARNESS INSTALLATION(WITH STERN DRIVE ENGINES)(FIG. 6.28.1)20. WIRE HARNESSESP

6.29SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)BONDING HARNESS INSTALLATION(WITH STERN DRIVE ENGINES)(FIG. 6.29.1)DRAWING NO. 09-204

6.30SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)BONDING HARNESS INSTALLATION(WITH OPTIONAL INBOARD/OUTBOARD ENGINES)(FIG. 6.30.1)DRAWI

6.31SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)BONDING HARNESS INSTALLATION(WITH OPTIONAL INBOARD/OUTBOARD ENGINES)(FIG. 6.31.1)DRAWI

320 Sundancer® (355 Sundancer®)xInformation in this publication is based upon the latest product specifications available at printing. SeaRay® Boats,

6.32SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)WIRE HARNESSES CONTINUEDBILGE HARNESS INSTALLATION(WITH STERN DRIVE ENGINES) (1 OF 3)(

6.33SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)WIRE HARNESSES CONTINUEDBILGE HARNESS INSTALLATION(WITH STERN DRIVE ENGINES) (2 OF 3)(

6.34SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)WIRE HARNESSES CONTINUEDBILGE HARNESS INSTALLATION(WITH STERN DRIVE ENGINES) (3 OF 3)(

6.35SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)WIRE HARNESSES CONTINUEDBILGE HARNESS INSTALLATION(WITH OPTIONAL V-DRIVE ENGINES) (1 O

6.36SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)WIRE HARNESSES CONTINUEDBILGE HARNESS INSTALLATION(WITH OPTIONAL V-DRIVE ENGINES) (2 O

6.37SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)WIRE HARNESSES CONTINUEDBILGE HARNESS INSTALLATION(WITH OPTIONAL V-DRIVE ENGINES) (3 O

6.38SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)WIRE HARNESSES CONTINUEDCABIN HARNESS INSTALLATION (1 OF 3)(FIG. 6.38.1)DRAWING NO. 09

6.39SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)WIRE HARNESSES CONTINUEDCABIN HARNESS INSTALLATION (2 OF 3)(FIG. 6.39.1)DRAWING NO. 09

6.40SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)WIRE HARNESSES CONTINUEDCABIN HARNESS INSTALLATION (3 OF 3)(FIG. 6.40.1)DRAWING NO. 09

6.41SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)WIRE HARNESSES CONTINUEDCEILING HARNESS INSTALLATION(FIG. 6.41.1)DRAWING NO. 09-875

1.1SECTION 1 • SAFETY320 Sundancer® (355 Sundancer®)SAFE boating means:• Knowing the limitations of your boat;• Following the rules of the road;• Kee

6.42SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)WIRE HARNESSES CONTINUEDSPOILER HARNESS INSTALLATION(FIG. 6.42.1)DRAWING NO. 09-887

6.43320 Sundancer® (355 Sundancer®)21. 320 DA Electrical Schematics21. 320 DA Electrical Schematics21. 320 DA Electrical Schematics21. 320 DA Elec

6.44320 Sundancer® (355 Sundancer®)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Conti

6.45320 Sundancer® (355 Sundancer®)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Conti

6.46320 Sundancer® (355 Sundancer®)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Conti

6.47320 Sundancer® (355 Sundancer®)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Conti

6.48320 Sundancer® (355 Sundancer®)DC WIRING DIAGRAM (V-DRIVE OPTION) (1 OF 5)(FIG. 6.48.1)320 DA Electrical Schematics (Continued)320 DA Electrical S

6.49320 Sundancer® (355 Sundancer®)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Conti

6.50320 Sundancer® (355 Sundancer®)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Conti

6.51320 Sundancer® (355 Sundancer®)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Conti

1.2SECTION 1 • SAFETY320 Sundancer® (355 Sundancer®)Fumes from engine, generators, and other equipmentand appliances using burning fuel contain carbon

6.52320 Sundancer® (355 Sundancer®)DC WIRING DIAGRAM (V-DRIVE OPTION) (5 OF 5)(FIG. 6.52.1)320 DA Electrical Schematics (Continued)320 DA Electrical S

6.53320 Sundancer® (355 Sundancer®)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Conti

6.54320 Sundancer® (355 Sundancer®)DC WIRING DIAGRAM (MERC DIESEL OPTION) (3 OF 4)(FIG. 6.54.1)DRAWING NO. 09-603 (3 OF 4)320 DA Electrical Schematics

6.55320 Sundancer® (355 Sundancer®)DC WIRING DIAGRAM (MERC DIESEL OPTION) (4 OF 4)(FIG. 6.55.1)320 D320 D320 D320 D320 DA ElectrA ElectrA ElectrA Elec

6.56320 Sundancer® (355 Sundancer®)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Conti

6.57320 Sundancer® (355 Sundancer®)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Conti

6.58320 Sundancer® (355 Sundancer®)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Conti

6.59320 Sundancer® (355 Sundancer®)CABIN DC WIRING SCHEMATIC (1 OF 2)(FIG. 6.59.1)DRAWING NO. 09-605 (1 OF 2) REVISION 3320 DA Electrical Schematics (

6.60320 Sundancer® (355 Sundancer®)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Conti

6.61320 Sundancer® (355 Sundancer®)WINDLASS WIRING SCHEMATIC (LOFRANS PROGRESS II)(FIG. 6.60.2)BOW THRUSTER WIRING DIAGRAM(FIG. 6.61.1)DRAWING NO. 09-

1.3SECTION 1 • SAFETY320 Sundancer® (355 Sundancer®)Even in rainy cold weather ventilation must bemaintained to avoid Carbon Monoxide poisoning. Youwi

6.62320 Sundancer® (355 Sundancer®)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Conti

6.63320 Sundancer® (355 Sundancer®)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Conti

6.64320 Sundancer® (355 Sundancer®)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Conti

6.65320 Sundancer® (355 Sundancer®)AC WIRING SCHEMATIC (220 VOLT / 50 HZ)(FIG. 6.65.1)DRAWING NO. 09-632 (1 OF 2) REVISION 1AC WIRING SCHEMATIC (220 V

6.66320 Sundancer® (355 Sundancer®)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Conti

6.67320 Sundancer® (355 Sundancer®)320 D320 D320 D320 D320 DA ElectrA ElectrA ElectrA ElectrA Electrical Scical Scical Scical Scical Schemahemahemahem

6.68320 Sundancer® (355 Sundancer®)D-TRONICS ENGINE MONITOR PANEL(FIG. 6.68.2)DRAWING NO. 09-913320 DA Electrical Schematics (Continued)320 DA Electri

6.69320 Sundancer® (355 Sundancer®)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Continued)320 DA Electrical Schematics (Conti

6.70320 Sundancer® (355 Sundancer®)TTTTTHISHISHISHISHIS P P P P PAAAAAGEGEGEGEGE L L L L LEFTEFTEFTEFTEFT I I I I INTENTIONNTENTIONNTENTIONNTENTIONNTE

SECTION 7 • OPTIONS & ACCESSORIES7.1320 Sundancer® (355 Sundancer®)1. LAYOUT AND ACCESSORY LOCATIONSPages 2.5 through 2.10 show the location a

1.4SECTION 1 • SAFETY320 Sundancer® (355 Sundancer®)EXAMPLES OF HOW HIGH LEVELS OF CARBONMONOXIDE MAY A CCUMULATE(FIG. 1.4.1)USING CANVAS CURTAINS.OPE

7.2SECTION 7 • OPTIONS & ACCESSORIES320 Sundancer® (355 Sundancer®)AIR CONDITIONING COMPONENT ARRANGEMENT(WITH STANDARD STERN DRIVE ENGINES)(FIG.

SECTION 7 • OPTIONS & ACCESSORIES7.3320 Sundancer® (355 Sundancer®)3. WATER SYSTEMThe fresh water system consists of a 40 gallon (151liter) water

7.4SECTION 7 • OPTIONS & ACCESSORIES320 Sundancer® (355 Sundancer®)WATER SYSTEM INSTALLATION(FIG.7.4.1)WATER HEATERWATER HEATER VENTTRANSOM SHOWER

SECTION 7 • OPTIONS & ACCESSORIES7.5320 Sundancer® (355 Sundancer®)WATER PUMP FILTER(FIG.7.5.2)BOWLFILTER SCREENO-RINGCOVERD. WATER PUMP AND FILTE

7.6SECTION 7 • OPTIONS & ACCESSORIES320 Sundancer® (355 Sundancer®)E. WATER HEATERThe water heater is located in the port side of theengine room.

SECTION 7 • OPTIONS & ACCESSORIES7.7320 Sundancer® (355 Sundancer®)SHOWER SUMP(FIG. 7.7.2)CONDENSATEHOSE FROM A/CSHOWERSUMP PUMPSHOWER & SINKD

7.8SECTION 7 • OPTIONS & ACCESSORIES320 Sundancer® (355 Sundancer®)WATER SYSTEM CONNECTIONS(INSIDE TRANSOM STORAGE COMPARTMENT)( FIG. 7.8.2)DOCKS

SECTION 7 • OPTIONS & ACCESSORIES7.9320 Sundancer® (355 Sundancer®)5. HEAD SYSTEMYour Sea Ray® is available with a variety of headsystem options.

7.10SECTION 7 • OPTIONS & ACCESSORIES320 Sundancer® (355 Sundancer®)D. VENT FILTERThe vent filter is designed to control odorsassociated with the

SECTION 7 • OPTIONS & ACCESSORIES7.11320 Sundancer® (355 Sundancer®)E. MACERATOR DISCHARGE PUMP WITHSEACOCK INTERLOCK SYSTEM (OPTIONAL)The macerat

1.5SECTION 1 • SAFETY320 Sundancer® (355 Sundancer®)Drugs and/or alcohol impair the operator’s ability tocontrol the boat safely.Death or serious inju

7.12SECTION 7 • OPTIONS & ACCESSORIES320 Sundancer® (355 Sundancer®)6. ENTERTAINMENT CENTERThe entertainment center equipment options mayvary fro

SECTION 7 • OPTIONS & ACCESSORIES7.13320 Sundancer® (355 Sundancer®)8. AUTOMATIC FIRE EXTINGUISHERSYSTEMYour boat is equipped withan automatic fir

7.14SECTION 7 • OPTIONS & ACCESSORIES320 Sundancer® (355 Sundancer®)MANUAL AUTOMATICFIRE EXTINGUISHING SYSTEMUpon system discharge, shut downEngin

SECTION 7 • OPTIONS & ACCESSORIES7.15320 Sundancer® (355 Sundancer®)10. POWER VENTILATION SYSTEMThe power ventilation system removes stagnant aira

7.16SECTION 7 • OPTIONS & ACCESSORIES320 Sundancer® (355 Sundancer®)CANVAS(FIG.7.16.1)SUNBRELLA®BIMINI TOPAFT SUNSHADESIDECURTAINSFRONTCURTAINSAFT

SECTION 7 • OPTIONS & ACCESSORIES7.17320 Sundancer® (355 Sundancer®)17. SPOT LIGHT (OPTIONAL)TO OPERATE THE SPOT LIGHT:1. Turn ON the SPOTLIGHT sw

7.18SECTION 7 • OPTIONS & ACCESSORIES320 Sundancer® (355 Sundancer®)18. BOW THRUSTER (OPTION)The optional bow thruster is electrically driven. The

SECTION 7 • OPTIONS & ACCESSORIES7.19320 Sundancer® (355 Sundancer®)19. AFT BERTH SLEEPING CONVERSIONTo convert the aft seating area into a bed:1.

7.20SECTION 7 • OPTIONS & ACCESSORIES320 Sundancer® (355 Sundancer®)THIS PAGE LEFT INTENTIONALLY BLANK

8.1SECTION 8 • REQUIRED INSPECTION, SERVICE ANDMAINTENANCE320 Sundancer® (355 Sundancer®)Routine inspection, service and maintenance of yourboat’s sys

1.6SECTION 1 • SAFETY320 Sundancer® (355 Sundancer®)Sea Ray Boats320 DAMAXIMUM12 + = 1360 kgC E0609BIMCIWhen engine is running, keep passengers away f

8.2SECTION 8 • REQUIRED INSPECTION, SERVICE ANDMAINTENANCE320 Sundancer® (355 Sundancer®)SUMMARY GUIDE FOR INSPECTION, SERVICE AND MAINTENANCE*Use in

8.3SECTION 8 • REQUIRED INSPECTION, SERVICE ANDMAINTENANCE320 Sundancer® (355 Sundancer®)2. USEFUL SERVICE INFORMATIONOWNERHOME PORTBOAT NAMEREGISTRAT

8.4SECTION 8 • REQUIRED INSPECTION, SERVICE ANDMAINTENANCE320 Sundancer® (355 Sundancer®)3. INSPECTION, SERVICE AND MAINTENANCE PROTOCOLA. BILGE AR

8.5SECTION 8 • REQUIRED INSPECTION, SERVICE ANDMAINTENANCE320 Sundancer® (355 Sundancer®)4. WINTERIZATION CHECKLIST FORBOATS STORED ON LANDA. BOAT ST

8.6SECTION 8 • REQUIRED INSPECTION, SERVICE ANDMAINTENANCE320 Sundancer® (355 Sundancer®)• Keep under a trickle charge.• When placing battery back int

8.7SECTION 8 • REQUIRED INSPECTION, SERVICE ANDMAINTENANCE320 Sundancer® (355 Sundancer®)6. SECURITY CONSIDERATIONSBe conscious of the security of you

8.8SECTION 8 • REQUIRED INSPECTION, SERVICE ANDMAINTENANCE320 Sundancer® (355 Sundancer®)SEACOCK(FIG. 8.8.1)OPENHOSEHOSE CLAMPSCLOSEDSEACOCKHANDLESEAC

8.9SECTION 8 • REQUIRED INSPECTION, SERVICE ANDMAINTENANCE320 Sundancer® (355 Sundancer®)8. QUICK REFERENCE CHECKLISTAs the owner/operator of a Sea Ra

8.10SECTION 8 • REQUIRED INSPECTION, SERVICE ANDMAINTENANCE320 Sundancer® (355 Sundancer®)QUICK REFERENCE CHECKLIST (CONT’D)*If engine fails to start,

8.11SECTION 8 • REQUIRED INSPECTION, SERVICE ANDMAINTENANCE320 Sundancer® (355 Sundancer®)C. WHILE UNDERWAYGENERAL1. Passengers/Crew ...

1.7SECTION 1 • SAFETY320 Sundancer® (355 Sundancer®)Distribute passengers and gear as uniformly aspossible from front to rear and left to right.The ma

8.12SECTION 8 • REQUIRED INSPECTION, SERVICE ANDMAINTENANCE320 Sundancer® (355 Sundancer®)QUICK REFERENCE CHECKLIST (CONT’D)3. Ignition ...

8.13SECTION 8 • REQUIRED INSPECTION, SERVICE ANDMAINTENANCE320 Sundancer® (355 Sundancer®)QUICK REFERENCE CHECKLIST (CONT’D)Do not run the generator o

8.14SECTION 8 • REQUIRED INSPECTION, SERVICE ANDMAINTENANCE320 Sundancer® (355 Sundancer®)9. AFTER MARKET EQUIPMENT CHECKLISTAny safety or operational

8.15SECTION 8 • REQUIRED INSPECTION, SERVICE ANDMAINTENANCE320 Sundancer® (355 Sundancer®)10. MAINTENANCE LOGFollow the recommended maintenance listed

8.16SECTION 8 • REQUIRED INSPECTION, SERVICE ANDMAINTENANCE320 Sundancer® (355 Sundancer®)MAINTENANCE LOG (CONT’D)Date Maintenance Description Engine

9.1SECTION 9 • CARE & REFINISHING320 Sundancer® (355 Sundancer®)Your new boat has been designed to provide youwith years of enjoyment and satisfac

9.2SECTION 9 • CARE & REFINISHING320 Sundancer® (355 Sundancer®)6. TOPSIDE AREASA. STAINLESS STEEL AND ALLOY FITTINGSStainless steel and alloy fit

9.3SECTION 9 • CARE & REFINISHING320 Sundancer® (355 Sundancer®)8. ACRYLIC PLASTIC SHEETING (PLASTIC GLASS)Never use a dry cloth or duster or g

9.4SECTION 9 • CARE & REFINISHING320 Sundancer® (355 Sundancer®)Always clean spots, stains, etc., immediately. Testan unseen area of fabric before

1.8SECTION 1 • SAFETY320 Sundancer® (355 Sundancer®)DO NOT ATTEMPT TO BOAT INSEVERE WEATHER CONDITIONSDEATH OR SERIOUS INJURY CAN OCCURGET TO SHORE BE

1.9SECTION 1 • SAFETY320 Sundancer® (355 Sundancer®)Shut engine off if an object is struck or if you runaground.Check for hull leaks and drive line da

1.10SECTION 1 • SAFETY320 Sundancer® (355 Sundancer®)Skiers must wear an approved PFD.! WARNINGSKIING SIGNALS(FIG. 1.10.1)OK AFTER FALL SKIER IN W

1.11SECTION 1 • SAFETY320 Sundancer® (355 Sundancer®)All boaters have a legal obligation to help otherboaters who are in distress, as long as renderin

1.12SECTION 1 • SAFETY320 Sundancer® (355 Sundancer®)F. GROUNDINGIn the event of running aground:• Check for leaks. If water is coming in, stop theint

1.13SECTION 1 • SAFETY320 Sundancer® (355 Sundancer®)18. INTERNATIONAL REQUIREMENTSThis vessel and its systems have been constructedin accordance with

1.14SECTION 1 • SAFETY320 Sundancer® (355 Sundancer®)19. NAUTICAL TERMSAbeam – object 90 degrees to center line on eitherside of boat.Abaft – a point

1.15SECTION 1 • SAFETY320 Sundancer® (355 Sundancer®)PROPULSIONSYSTEMTRIMPROPULSIONSYSTEM TRIMBOW UPPROPULSIONSYSTEM TRIMBOW DOWNTRIM TABTRIMMINGOPERA

1.16SECTION 1 • SAFETY320 Sundancer® (355 Sundancer®)• There is a possibility of being fined for having anoperable direct overboard discharge of waste

1.17SECTION 1 • SAFETY320 Sundancer® (355 Sundancer®)C. EXCESSIVE NOISEMany areas regulate noise limits. Even if thereare no laws, courtesy demands t

i320 Sundancer® (355 Sundancer®)Congratulations on becoming the new owner of theworld’s most prestigious boat. We at Sea Ray® Boats,Inc. welcome you i

1.18SECTION 1 • SAFETY320 Sundancer® (355 Sundancer®)THIS PAGE LEFT INTENTIONALLY BLANK

1.19320 Sundancer® (355 Sundancer®)WARNING LABEL LOCATIONS(FIG. 1.19.1)STAINLESS STEEL SLIDING SWIM LADDERSSUGGESTED CARE & MAINTENANCEMRP 157311

1.20320 Sundancer® (355 Sundancer®)12VDC-15A MAXMRP # 324756 SR-47Warning Label Locations (Continued)WARNING LABEL LOCATIONS(FIG. 1.20.1)THIS TAG INST

1.21320 Sundancer® (355 Sundancer®)Warning Label Locations (Continued)WARNING LABEL LOCATIONS(FIG. 1.21.1)Save Our SeasIt is illegal to dump plastic t

1.22320 Sundancer® (355 Sundancer®)THIS PAGE LEFT INTENTIONALLY BLANK

2.1SECTION 2 • GENERAL BOAT ARRANGEMENT320 Sundancer® (355 Sundancer®)Do Not use cleats for lifting.! CAUTIONCLEAT / BOW & STERN EYE LOCATIONS(

2.2SECTION 2 • GENERAL BOAT ARRANGEMENT320 Sundancer® (355 Sundancer®)Boat motion can be erratic.You can fall overboard or be injured by hittingsometh

2.3SECTION 2 • GENERAL BOAT ARRANGEMENT320 Sundancer® (355 Sundancer®)PASSENGER LOCATIONS(FIG. 2.3.1)WORKING DECK(DECK AREA INTENDED FOROCCUPATION DU

2.4SECTION 2 • GENERAL BOAT ARRANGEMENT320 Sundancer® (355 Sundancer®)4. OPTIONAL PROPULSION SYSTEMThe optional engine is an inboard V-drive typepropu

2.5SECTION 2 • GENERAL BOAT ARRANGEMENT320 Sundancer® (355 Sundancer®)5. BASIC BOAT DIMENSIONS AND CLEARANCESBOAT DIMENSIONS AND CLEARANCES(FIG. 2.5.

320 Sundancer® (355 Sundancer®)ii

2.6SECTION 2 • GENERAL BOAT ARRANGEMENT320 Sundancer® (355 Sundancer®)6. DECK LAYOUT (UPPER DECK)GENERAL LAYOUT(FIG. 2.6.1)STBD NAVIGATIONLIGHTPORT N

2.7SECTION 2 • GENERAL BOAT ARRANGEMENT320 Sundancer® (355 Sundancer®)DECK LAYOUT (MID DECK/CABIN) (CONTINUED)GENERAL LAYOUT(FIG. 2.7.1)HEAD SINKSTOVE

2.8SECTION 2 • GENERAL BOAT ARRANGEMENT320 Sundancer® (355 Sundancer®)EFFuelEFFuelPORTENGINESYNCHRONIZERSTBD0102030405060RPMX10000000HOURS0

2.9SECTION 2 • GENERAL BOAT ARRANGEMENT320 Sundancer® (355 Sundancer®)TRIM TABSWITCHESENGINEIGNITIONSWITCH(START)HATCHLIFTTRIM TABSFORWARDACCESSORYAFT

2.10SECTION 2 • GENERAL BOAT ARRANGEMENT320 Sundancer® (355 Sundancer®)8. FUNCTION AND LOCATION OF THROUGH-HULL CUTOUTSSTARBOARD THROUGH-HULL CUTOUTS(

2.11SECTION 2 • GENERAL BOAT ARRANGEMENT320 Sundancer® (355 Sundancer®)Cockpit can fill with water if boat is moving forward,when it is put into rever

2.12SECTION 2 • GENERAL BOAT ARRANGEMENT320 Sundancer® (355 Sundancer®)B. TRIM TABSThe trim tabs are two flatplates, hinged below the waterline on the

2.13SECTION 2 • GENERAL BOAT ARRANGEMENT320 Sundancer® (355 Sundancer®)TACHOMETER WITH HOURMETER(FIG. 2.13.2)Always check oil pressure and water gauge

2.14SECTION 2 • GENERAL BOAT ARRANGEMENT320 Sundancer® (355 Sundancer®)1001301702205580F/ C0080400420280140PSI/kPa10121418UPDNB. OIL PRESSURE, WATERTE

2.15SECTION 2 • GENERAL BOAT ARRANGEMENT320 Sundancer® (355 Sundancer®)11. NAVIGATION AND ANCHOR LIGHTSNavigation lights (Figure 2.15.1) MUST be on wh

iii320 Sundancer® (355 Sundancer®)INTRODUCTION1. THIS MANUALThe material here and in the rest of the Owner’sManual Packet:• Gives you basic safety inf

2.16SECTION 2 • GENERAL BOAT ARRANGEMENT320 Sundancer® (355 Sundancer®)THIS PAGE LEFT INTENTIONALLY BLANK

3.1SECTION 3 • USING YOUR BOAT320 Sundancer® (355 Sundancer®)1.PRE-LAUNCH, LAUNCH AND POST-LAUNCH CHECKLISTListed below are the critical items you mus

3.2SECTION 3 • USING YOUR BOAT320 Sundancer® (355 Sundancer®)FUEL FILL LOCATION(FIG. 3.2.1)NO SMOKINGGASOLINE VAPORS ARE EXPLOSIVE! DANGERNOTICEGAS

3.3SECTION 3 • USING YOUR BOAT320 Sundancer® (355 Sundancer®)Wet decks are slippery.You can be seriously injured if you slip and fall.Wear slip-resist

3.4SECTION 3 • USING YOUR BOAT320 Sundancer® (355 Sundancer®)(FIG. 3.4.1) Gasoline vapors can explodeBefore starting the engines, open enginecompartme

3.5SECTION 3 • USING YOUR BOAT320 Sundancer® (355 Sundancer®)9. Put throttle into idleposition and shift controllever into neutral; then fora:COLD ENG

3.6SECTION 3 • USING YOUR BOAT320 Sundancer® (355 Sundancer®)Cockpit can fill with water if boat is moving forward,when it is put into reverse.Before

3.7SECTION 3 • USING YOUR BOAT320 Sundancer® (355 Sundancer®)POWER STEERING SYSTEM(FIG. 3.7.1)POWER STEERINGCYLINDERSTEERINGWHEELCHECK & ADDFLUID

3.8SECTION 3 • USING YOUR BOAT320 Sundancer® (355 Sundancer®)10. STEERING SYSTEM(WITH OPTIONAL V-DRIVE ENGINES)The hydraulic steering system is used p

3.9SECTION 3 • USING YOUR BOAT320 Sundancer® (355 Sundancer®)STARBOARDENGINETHROTTLECABLEPORT ENGINETHROTTLECABLEPORT ENGINESHIFTCABLESTARBOARDENGINES

320 Sundancer® (355 Sundancer®)ivIf you do not receive all of these materials, or haveany questions, contact your dealer or call:1-800-SRBOATS.5. WARR

3.10SECTION 3 • USING YOUR BOAT320 Sundancer® (355 Sundancer®)WINDLASS (MAINTENANCE PROFILE)(FIG. 3.10.4)EMERGENCY HANDLECLUTCH NUTDRUMUPPER CONECHAI

3.11SECTION 3 • USING YOUR BOAT320 Sundancer® (355 Sundancer®)B. TO OPERATE FROM THE BOW:• Make sure that the safety lanyard is removedfrom the anchor

3.12SECTION 3 • USING YOUR BOAT320 Sundancer® (355 Sundancer®)THIS PAGE LEFT INTENTIONALLY BLANK

4.1SECTION 4 • BILGE & UNDERWATER GEAR320 Sundancer® (355 Sundancer®)1. BILGEA. FUEL & OIL SPILLAGERegulations prohibit discharging fuel or oi

SECTION 4 • BILGE & UNDERWATER GEAR4.2320 Sundancer® (355 Sundancer®)Before starting the engine, press the bilge pumpswitch so that the switch lig

4.3SECTION 4 • BILGE & UNDERWATER GEAR320 Sundancer® (355 Sundancer®)E. BILGE BLOWERSTo prevent buildup of gasoline fumes to theexplosive level in

SECTION 4 • BILGE & UNDERWATER GEAR4.4320 Sundancer® (355 Sundancer®)BILGE PUMP LOCATION & HOSE ROUTING / BLOWER LOCATION & HOSE ROUTING(W

4.5SECTION 4 • BILGE & UNDERWATER GEAR320 Sundancer® (355 Sundancer®)BILGE PUMP LOCATION & HOSE ROUTING / BLOWER LOCATION & HOSE ROUTING(W

SECTION 4 • BILGE & UNDERWATER GEAR4.6320 Sundancer® (355 Sundancer®)2. ENGINESThe engines on the 320 Sundancer® are the heartof your Sea Ray®. Pr

4.7SECTION 4 • BILGE & UNDERWATER GEAR320 Sundancer® (355 Sundancer®)4. MARINE GEARSA. REDUCTION GEARSA reduction gear reduces the rotating speed

v320 Sundancer® (355 Sundancer®)8. SERVICE, PARTS AND REPAIR FORYOUR BOATWhen your boat needs service, parts or repair, take itto an authorized Sea Ra

SECTION 4 • BILGE & UNDERWATER GEAR4.8320 Sundancer® (355 Sundancer®)5. ENGINE EXHAUST SYSTEM(WITH OPTIONAL INBOARD V-DRIVE)The underwater exhaust

4.9SECTION 4 • BILGE & UNDERWATER GEAR320 Sundancer® (355 Sundancer®)6. ENGINE REMOVALShould the removal of an engine becomenecessary, see your S

SECTION 4 • BILGE & UNDERWATER GEAR4.10320 Sundancer® (355 Sundancer®)7. VIBRATION & CAUSESSome vibration is to be expected in your boatbecaus

4.11SECTION 4 • BILGE & UNDERWATER GEAR320 Sundancer® (355 Sundancer®)9. UNDERWATER GEARA. PROPELLER GENERAL INFORMATIONPropellers should be free

SECTION 4 • BILGE & UNDERWATER GEAR4.12320 Sundancer® (355 Sundancer®)PROPELLER(FIG. 4.12.2)SECURINGTABSIf engine is started during propeller main

4.13SECTION 4 • BILGE & UNDERWATER GEAR320 Sundancer® (355 Sundancer®)If the jam nut and prop nut are installed properly,the propeller should not

SECTION 4 • BILGE & UNDERWATER GEAR4.14320 Sundancer® (355 Sundancer®)Jam NutShaft Thread Prop Torque TorqueDiameter Size Nut Ft. Lbs. Ft. Lbs.1&q

4.15SECTION 4 • BILGE & UNDERWATER GEAR320 Sundancer® (355 Sundancer®)HOSE CLAMPSFLEXIBLE HOSEHULLSTAINLESS STEELBANDSSTRONG SEAL™SHAFT LOGWATERIN

SECTION 4 • BILGE & UNDERWATER GEAR4.16320 Sundancer® (355 Sundancer®)E. CARRIER SEAL KIT(WITH OPTIONAL INBOARD V-DRIVE ENGINES)Your 320 Sudancer®

4.17SECTION 4 • BILGE & UNDERWATER GEAR320 Sundancer® (355 Sundancer®)WINGNUTO-RINGSCREENHANDLESTRAINERSEACOCKSEACOCK &STRAINER(FIG. 4.17.3)As

320 Sundancer® (355 Sundancer®)viABOUT YOUR LIMITED WARRANTYSea Ray offers an express Limited Warranty on eachnew Sea Ray purchased through an authori

SECTION 4 • BILGE & UNDERWATER GEAR4.18320 Sundancer® (355 Sundancer®)STRAINER MAINTENANCE(FIG. 4.18.1)STRAINER MAINTENANCE(FIG. 4.18.2)STRAINER M

4.19SECTION 4 • BILGE & UNDERWATER GEAR320 Sundancer® (355 Sundancer®)BILGE LAYOUT (WITH STANDARD INBOARD/OUTBOARD ENGINES)(FIG. 4.19.1)12. BILGE

SECTION 4 • BILGE & UNDERWATER GEAR4.20320 Sundancer® (355 Sundancer®)BILGE LAYOUT (CONTINUED)BILGE LAYOUT (WITH V-DRIVE ENGINE OPTION)(FIG. 4.20.

5.1SECTION 5 • FUEL SYSTEM320 Sundancer® (355 Sundancer®)1. FUEL SYSTEMSection 3 - Using Your Boat contains importantfueling information. Take time to

5.2SECTION 5 • FUEL SYSTEM320 Sundancer® (355 Sundancer®)B. DIESEL FUEL SYSTEM (WITH DIESELENGINE OPTION)The diesel fuel system consists of two fuel t

5.3SECTION 5 • FUEL SYSTEM320 Sundancer® (355 Sundancer®)B. TO REPLACE THE FILTER:1. Shut down the engine.2. Remove the lid .3. Remove the old rubber

5.4SECTION 5 • FUEL SYSTEM320 Sundancer® (355 Sundancer®)FUEL FILL LOCATION(FIG. 5.4.1)3. FUELING PRECAUTIONSCertain precautions must be carefully an

5.5SECTION 5 • FUEL SYSTEM320 Sundancer® (355 Sundancer®)STARBOARDFUEL TANK FILLENGINE FUEL LINE ROUTING (PORT VIEW)(FIG. 5.5.1)STARBOARDFUEL TANKELEC

5.6SECTION 5 • FUEL SYSTEM320 Sundancer® (355 Sundancer®)THIS PAGE LEFT INTENTIONALLY BLANK

6.1SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)1. ELECTRICAL SYSTEMA. DIRECT CURRENT (DC)The 12 volt direct current (DC) electrical sy

vii320 Sundancer® (355 Sundancer®) • TABLE OF CONTENTS •INTRODUCTION1. This Manual ... iii2.

6.2SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)BATTERY CABLE ROUTING (WITH STANDARD INBOARD/OUTBOARD ENGINES)(FIG. 6.2.2)PORTSTBDFWDBA

6.3SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)BATTERY CABLE ROUTING (WITH STANDARD INBOARD/OUTBOARD ENGINES)(FIG. 6.3.1)PORTSTBDFWD

6.4SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)BATTERY CABLE ROUTING (WITH OPTIONAL V-DRIVE ENGINES)(FIG. 6.4.2)PORTSTBDFWDBATTERY INS

6.5SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)BATTERY CABLE ROUTING (WITH OPTIONAL V-DRIVE ENGINES)(FIG. 6.5.1)PORTSTBDFWDBOW THRUSTE

6.6SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)GASOLINE VAPORS CAN EXPLODE! DANGERUse ONLY Marine-rated parts to replace such itemsa

6.7SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)MAIN DC BREAKER PANEL (LOCATED ON THE FORWARD BULKHEAD IN THE ENGINE ROOM)(FIG. 6.7.1)1

6.8SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)MAIN DC DISTRIBUTION PANEL LOCATIONS(FORWARD ENGINE ROOM BULKHEAD) (FIG. 6.8.1)EMERGEN

6.9SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)CABIN DC BREAKER PANEL (LOCATED IN THE CABINET AFT OF DINETTE/SOFA)(FIG. 6.9.1)12 Volt

6.10SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)6. ELECTRIC SWITCHING SYSTEMThe 320 DA is equipped with illuminated waterproofelectron

6.11SECTION 6 • ELECTRICAL SYSTEM320 Sundancer® (355 Sundancer®)ELECTRONIC INTERFACE MODULES (EIM)(FIG. 6.11.1)AFT ELECTRONIC INTERFACE MODULE (EIM)(L